Home   |  Message Board   |  Information   |  Classifieds   |  Features   |  Video
Replacing tires based on age. - Walleye Message Central
Walleye Message Central

Go Back   Walleye Message Central > Boats, Motors, Electronics and Trailers > Trailers

Reply
 
Thread Tools Display Modes
  #1  
Old 02-03-2009, 01:26 PM
Redpete Redpete is offline
Minnow
 
Join Date: Jun 2003
Location: Shoreview, MN, USA.
Posts: 50
Default Replacing tires based on age.

I only put a couple of thousand miles on my trailer every year.

The tires are many years old, but still have lots of tread.

The boat/trailer is in a garage when the boat is not in the water, so sitting in the sun is not an issue.

The boat is a Lund 1650 Explorer SS with a 70 HP Honda and the trailer is a 2400 pound Shorelandr, so I don't think I am overloading the trailer.

After how many years should I replace the tires even when they look fine?

Thanks.
Reply With Quote Quick reply to this message
Sponsored Links
Advertisement
 
  #2  
Old 02-03-2009, 05:04 PM
ffishman's Avatar
ffishman ffishman is offline
Wallhanger
 
Join Date: Sep 2004
Location: Schaumburg, ILL, USA.
Posts: 6,367
Default

The "tire makers" recommend every 6 years, but I think that is excessive. But I think by 8 years its time. From what I have read, the material just breaks down. The tire looks good, but is weak and likely to fail.
Reply With Quote Quick reply to this message
  #3  
Old 02-03-2009, 07:20 PM
Modog Modog is offline
Wallhanger
 
Join Date: Mar 2006
Location: Wisconsin.
Posts: 956
Default also

The age should be established from the tires manufactured date on the sidewall, not from the time they were put into service on the trailer.
Reply With Quote Quick reply to this message
  #4  
Old 02-04-2009, 07:19 AM
yarcraft91's Avatar
yarcraft91 yarcraft91 is online now
Wallhanger
 
Join Date: Oct 2005
Location: Somewhere in the middle of..., Michigan.
Posts: 6,997
Default

The answer is "How lucky do you feel?". I had a rowboat trailer with 25 year-old tires that I towed 3500 miles to Canada and back 4 years ago without incident. The original tires on my big boat trailer were 15 years-old when I replaced them. Both trailers are stored indoors when not in use, most of my towing is short trips at moderate speeds, the tires are loaded to less than 85% of capacity and the tires still looked good with no weather-checking. I've been lucky, but now that I've heard many stories about failures of old tires that looked perfectly good, I'm changing my behavior.

I got nervous on the big trailer and put on new radials and will probably replace them every 6 years to be on the safe side. The consequences of a tire failure at freeway speeds outweigh the cost of replacing tires. If the small trailer ever goes on a trip again, it also gets new tires.
Reply With Quote Quick reply to this message
  #5  
Old 02-07-2009, 09:32 AM
oldntired oldntired is offline
Minnow
 
Join Date: Jun 2008
Location: .Montana
Posts: 57
Default

If your tires have been covered they will last for many years. If they have weather checking around the beads or on the sidewalls then they are likely to give you problems.
Reply With Quote Quick reply to this message
  #6  
Old 02-07-2009, 04:25 PM
bridgeman's Avatar
bridgeman bridgeman is online now
Keeper
 
Join Date: Apr 2004
Location: PA.
Posts: 435
Default

I have probably had more blow-outs than most on this site but I've been trailering 200+ miles one way for 30 years now, until I started replacing my tires every 5 years. Years ago I had money for beer but not tires and beer. It's not any fun replacing a tire on the interstate at 2 in the morning.
Reply With Quote Quick reply to this message
  #7  
Old 02-08-2009, 09:33 AM
REW REW is offline
Charter Member
 
Join Date: Nov 1999
Location: .
Posts: 24,488
Default

The best rule of thumb is to replace the tires 6 years after the date of manufacture.

It doesn't make any difference if they have been covered, if their is weather checking, if there is one mile of use on the tires.

Replace them every 6 years and you will likely be trouble free on the roads.

Go longer and you are rolling the dice - on your chances of getting to your destination and back without issue.

--------------
I wasn't a believer in this idea until I had three tires blow out on a trip with my motor home on tires that were 8 years old, but had 90% tread on them and no signs of checking or other issues.

It seems that the compunds in rubber simply break down over time - whether visible or not and thus weaken the tires.

I would suggest that if you have tires on your trailer that have a 100% safety factor - for example a tire that is carrying 2000 lbs with a 4000 lb rating, you are likely to go much longer without issue.

I suspect that the most problems are going to be with tires that are running at or near their max load rating as was the case with my motor home.

Take care
REW
Reply With Quote Quick reply to this message
  #8  
Old 02-08-2009, 09:35 AM
REW REW is offline
Charter Member
 
Join Date: Nov 1999
Location: .
Posts: 24,488
Default

p.s.
If you do blow a tire at 70 mph - on a trailer, vehicle or other - and expecially if the tire is a steel belted radial - I assure you that the long steel belt flapping around for a few seconds at 70 mph - causes a huge amount of damage.

i.e. ripping up fenders, ripping up undercarriage, ripping up anything that comes in contact with the high speed heavy long steel belt flying around under the vehicle or trailer.

Take care
REW
Reply With Quote Quick reply to this message
  #9  
Old 02-08-2009, 09:41 AM
REW REW is offline
Charter Member
 
Join Date: Nov 1999
Location: .
Posts: 24,488
Default

Redpete.
Do yourself a favor to check on tire loads.
Put everthing that you normally put in your trailer for any of your typical trips. If you don't put anything in the trailer, fine. If you do as most folks do and load the trailer up pretty good - do so.

Then, take the trailer over to a vehicle scale and weigh the vehicle by axle and also weigh the trailer by axle.

You can easily find scales at freeway weigh stations, some truck stops, garbage transfer stations, recycling centers, etc. etc.

Once you have weighed the vehicle and trailer by axle - divide that number by the number of tires on that particular axle.

Record all of these numbers for future reference.

Then, compare each of these numbers to the max load numbers that are printed on the sides of the tires.

Then, and only then you will know with certainity - what safety margin, if any you have on your vehicle and trailer tires.

It is a very very very common thing to have trailer tires carrying a load that is a little or much greater than the max load rating that is imprinted on the side of the tire.

--
If you find this to be true, replace the tires with tires having a larger load rating, or change the trailer to a larger trailer with larger tires, better able to carry the load.

--
My guess is - as is yours - that you are fine. Your description of your rig sounds like you are likely just fine with the loading. However, it is certainly a good idea to check, just to be sure on the loading.

Take care
REW
Reply With Quote Quick reply to this message
  #10  
Old 02-14-2009, 08:51 PM
prov1900's Avatar
prov1900 prov1900 is offline
Keeper
 
Join Date: Jul 2006
Location: Nebraska.
Posts: 385
Default

Timely topic. I was just trying to figure out the load thing today after I was bored and checked the inflation on my tires. Ironically, they looked fine from the outside, but they were really low. I have a dual axle Eagle with marathons...205/75R14.

My Lund IFS weighs (according to the Lund webpage) at approximately 1875 pounds. The tires are rated at approximately 1760 pounds.

REW, roughly, and I mean roughly, where do I sit with four tires (2 axles)? How much does that take off or compensate for the load?
Reply With Quote Quick reply to this message
Reply

Quick Reply
Message:
Options

Register Now

In order to be able to post messages on the Walleye Message Central forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Thread Tools
Display Modes

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is Off
HTML code is Off

Forum Jump


All times are GMT -6. The time now is 02:38 PM.